LTI Maintenance Flashcards
Daily Schedule Check List: fuel, engine oil, coolant, onan oil, onan coolant - maintain to ________
Capacity
Daily Schedule Check List: Brakes, air reservoir psi - verify PSI in primary & secondary tanks are at least ___ psi at start of shift. Perform ______ test
90
COLA
Daily Schedule Check List: Tires/Wheels - ________ check wheels & tires.
Visual
Daily Schedule Check List: Signal & lighting system - inspect ______ lights for proper operation.
ALL
Daily Schedule Check List: Electrical system - check voltage with engine off & all Electrical accessories off ( ___ Volts min). Start engine, engage high idle & check voltage again ( ___ Volts min).
12.9
13.7
Daily Schedule Check List: Engine - look for any signs of fluid ______.
Leakage
Daily Schedule Check List: Running Gear - look for ________/________ of bolts, nuts, fittings, shafts, cables, etc.
Condition/Tightness
Daily Schedule Check List: Seat Belts - look for ______/______. Check latch mechanism & integrity of mounts.
Cuts/Deterioration
Weekly Schedule Check List: Engine - set ______ ______ with AC at max cool & all elect. accessories on. Monitor gauges inspect for leaks
High Idle
Weekly Schedule Check List: Engine - de-activate ______ ______ set high idle, run ___ mins.
Load Manager
10
Weekly Schedule Check List: Parking Brake - set parking brake & place transmission in ___. Remove pressure from ______ pedal & observe if brakes hold apparatus
D
Brake
Weekly Schedule Check List: Brakes - Thickness less than ___” note & report schedule brake job
1/4
Weekly Schedule Check List: Aux Front Wheel Lock - when the engine ____ & wheels ______ have assistant observe axel brake activation & listen for leaks
Off
Chocked
Weekly Schedule Check List: transmission fluid - perform manual “______ ______” of transmission fluid
Cold Check
Weekly Schedule Check List: Emergency Power Unit (EPU) - ______ EPU, circulate fluid, check operation and check for leaks.
Run
Weekly Schedule Check List: Aerial swing drive - remove pipe plug located near top of swing drive. ______ should be above top face of gear, but not higher than bottom of plug opening, refill as needed.
Oil
Weekly Schedule Check List: Axle hub - ___-___ check fluid level.
00’-06’
Weekly Schedule Check List: Aerial ladder - ______ aerial and outriggers.
Operate
Weekly Schedule Check List: fifth wheel pivot shafts - ________ at each pivot shaft zerk
Lubricate
Bi-Monthly Preventative Maintenance Record (F-377) - proper maintenance is dependent on
_______________
_______________
Orderly procedure
Established inspection routine
Bi-Monthly Preventative Maintenance Record (F-377) - perform every _____ month within the first ____ weeks of every ______ month on heavy apparatus
Other
Two
EVEN
Bi-Monthly Preventative Maintenance Record (F-377) - minimum requirements
Fill out the ______ form
______ ______ review and sign it
Retain ______ copy & keep in the logbook
The other copy goes to the ______ ______ for filing
F-377
Station Commander
One
Station Commander
Bi-Monthly Preventative Maintenance Record (F-377) - F-377 applies to all ______ & ______ Apparatus & trailers (active, reserve, & standby)
Light
Heavy
Bi-Monthly Preventative Maintenance Record (F-377) - items in good condition, not in need of service shall be marked ____ in designated column
OK
Bi-Monthly Preventative Maintenance Record (F-377) - when calling in repairs log, on F-377, name the ______ contacted, ______ received & ______
Name
instructions
Date
Bi-Monthly Preventative Maintenance Record (F-377) - for reserve apparatus if use is limited fill out only checks that are necessary. Entire F-377 shall be completed on those during ____ oil change.
6-Month
F-377 Instructions: Steering Box & Steering Linkage - position front wheels straight forward & have assistant move steering wheel back and forth with short ___ TO ___ rapid movements.
40 TO 60
F-377 Instructions: Differential - check ______ level
Oil
F-377 Instructions: air cleaner - replace every ______ year
Other
F-377 Instructions: Coolant System - coolant should be ______
Green
F-377 Instructions: Drive belts - report defect if belt tension is lose enough to allow more than ____” deflection measured at a point midway between pulleys.
1/2”
F-377 Instructions: Tires - a reading of _____” or less should be reported on the F-377 & called in for needing replacement.
1/8”
F-377 Instructions: Tire maintenance & replacement - when tread depth is at or less than ___”
4/32
Tire Pressure: ALF 06’-09’
Front PSI ___
Rear PSI ___
Tiller PSI ___
100
95
115
Tire Pressure: ALF 00’-03’’
Front PSI ___
Rear PSI ___
Tiller PSI ___
100
95
110
Tire Pressure: Simon LTI 95’ & 96’
Front PSI ___
Rear PSI ___
Tiller PSI ___
105
100
110
Tire Pressure: Simon LTI 93’
Front PSI ___
Rear PSI ___
Tiller PSI ___
110
90
110
FlUID TYPE: Engine oil ___W-___
15W-40
FlUID TYPE: Road Transmission - ___ (dexron II)
ATF
FlUID TYPE: Drive Axle & Hub ___W-___ oil
90W-140
FlUID TYPE: Engine Coolant - supplied by ____
S&M
FlUID TYPE: Power Steering (2 reservoirs) ___W-___ motor oil
15W-40 06-09’
ATF 00’-03’
FlUID TYPE: Aerial Hydraulic Reservoir - ___ Hyd. oil ___ chevron
AW 32
FlUID TYPE: Cab Lift Hydraulic ___ (dexron II)
ATF
FlUID TYPE: Onan Generator Oil ___W-___ motor oil
15W-40
FlUID TYPE: Onan Generator Coolant - supplied by ___
S&M
FlUID TYPE: Swing Drive ___W Gear Oil
90
Brake Caliper Assembly - takes special, high temp, high-pressure grease required by ________. The shops will lube these parts at __________________ or whenever brake job is performed
Rockwell
Annual Pump Test
Fifth Wheel - when lubricating, inject grease with the tractor inline, at ___° degrees to the left and right of the trailer.
60°
Aerial Ladder - when done lubing, hoist ladder to ___° degrees and retract to prevent newly applied grease form being scrape off.
60°
F-377 Bi-Monthly Inspection List: Brakes - Inspect brake push rod travel for a maximum ___” stroke on all six wheels
2
F-377 Bi-Monthly Inspection List:
Note and record current
• ___________
• ___________
• ___________
• ___________
• Odometer Reading
• Engine Hours
• Aerial Hours
• Generator Hours
Annual performance test record shall be retained for?
Permanently
The addendum section is used for any addendum, updates or changes that may occur department wide or specific __________, __________ or __________
Apparatus
Tools
Equipment
The cab lift holds ___ quarts of ATF?
4
