*'16 Pierce Arrow XT

Question 1

What type of Engine? HP?

Answer 1

Cummins ISX 15 912 in3 displacement (14.9L) 550hp @ 1800 rpm

Question 2

What transmission?

Answer 2

Allison 4500 EVS

Question 3

Front Axle weight rating?

Answer 3

20,000 lbs

Question 4

Rear Axle weight rating?

Answer 4

31,000 lbs

Question 5

Tiller Axle weight rating?

Answer 5

22,800 lbs 23,200 lbs (plaque)

Question 6

Diesel Fuel Tank size?

Answer 6

63 gal

Question 7

DEF tank size?

Answer 7

4.5 gal

Question 8

Engine oil capacity?

Answer 8

44 qt

Question 9

Engine coolant capacity? Reservoir?

Answer 9

65 pts (16.25 gal). 6 qt in reservoir

Question 10

Aerial Hydraulic fluid total and in reservoir?

Answer 10

80gal total. 40gal in reservoir

Question 11

Load Manager - what sheds and at what point?

Answer 11

Inverter @ 12.4v (12.6v unshed) Heat/AC @ 12.2v (12.4v unshed)

Question 12

Aerial ladder tip capacity?

Answer 12

500 lbs

Question 13

Safe Operating Limits - Full Capacity

Answer 13

0 to 5 degrees

Question 14

Safe Operating Limits - Half Capacity

Answer 14

5.1 to 8 degrees

Question 15

Safe Operating Limits - Zero Capacity

Answer 15

> 8 degrees

Question 16

Jack knife collision warnings?

Answer 16

65 and 85 degrees

Question 17

At what pressure do the spring brakes automatically apply?

Answer 17

Approximately 40 psi

Question 18

Trailer should be within __ degrees of tractor for aerial operations? No jack knifing required.

Answer 18

30

Question 19

The area where the ground pads make contact with the ground must be firm and capable of supporting __ psi.

Answer 19

75

Question 20

Low air alarm activates when air in either tank is less than approximately __ psi

Answer 20

60

Question 21

Downhill Operating/Heavy Braking: If service brakes are required to supplement retardation, apply the brakes in short durations of __ to __ seconds rather than a continuous application.

Answer 21

5 to 10

Question 22

Excessive Idling is considered more than __ minutes per the log book.

Answer 22

5

Question 23

Preheat the generator according to ambient temperature for how long?

Answer 23

— 10 seconds - above 50°F — 15 seconds - 0°F to 50°F — 20 seconds - below 0°F

Question 24

Make, model and output of generator?

Answer 24

Cummins ONAN. 7500w

Question 25

Power inverter rating?

Answer 25

1125w

Question 26

Load shedding: Shed point minimum of __ minute. The shed load will remain off for __ minutes and will not unshed until the unshed voltage is achieved for __ minute.

Answer 26

1 minute 5 minutes 1 minute

Question 27

Loads will only shed when? 2 things enabled.

Answer 27

Load manager Enabled. Parking brake set.

Question 28

Low Fuel Warning light turns on at?

Answer 28

1/8th of a tank

Question 29

Battery terminals can be cleaned with?

Answer 29

Hot water and baking soda

Question 30

Hydraulic system standby pressure?

Answer 30

350 psi

Question 31

Max pressure of hydraulic system?

Answer 31

3000 psi

Question 32

The Vehicle Data Record is capable of storing the most recent ___ hours of vehicle information.

Answer 32

100 hours

Question 33

The EPU (Emergency Pump Unit) can run for a max of __ minutes continuously.

Answer 33

30 minutes

Question 34

The aerial ladder has a safety factor of __ to 1.

Answer 34

2 to 1

Question 35

Max wind capacity of aerial ladder?

Answer 35

50 mph

Question 36

Degrees of elevation of aerial ladder?

Answer 36

-5 to 75 degrees

Question 37

Rated horizontal reach of aerial ladder? 0 degrees? 45 degrees? 75 degrees?

Answer 37

95' 1" @ 0 degrees 66' 9" @ 45 degrees 23' 11" @ 75 degrees

Question 38

Diesel engines consume as much as ____ cubic feet of clean air every minute when operating under full load.

Answer 38

1200 ft3

Question 39

A diesel truck engine may consume over _____ gallons of air for every gallon of fuel that it burns.

Answer 39

12,500

Question 40

Length of Truck?

Answer 40

55'10" 55’8” plaque in truck

Question 41

Height of Truck to top of Tiller Cab?

Answer 41

11'3" 11’ 2.5” per plaque

Question 42

Overhang?

Answer 42

Approximately 9'3"

Question 43

Load Manager activates high idle at what voltage?

Answer 43

12.8 v

Question 44

If the engine does not start within __ seconds, release the starter buttons and allow the starter motor to cool for __ seconds before attempting to start the engine again.

Answer 44

15, 60

Question 45

Transmission sump max operating temperature

Answer 45

250 degrees

Question 46

Transmission normal operating range?

Answer 46

160 - 200 degrees

Question 47

GVWR. Gross Vehicle Weight Rating

Answer 47

74,500 lbs 37.25 tons

Question 48

Tire pressure

Answer 48

120psi all tires

Question 49

Tire-limited max speed

Answer 49

65 mph