Volume 2b Flashcards by barrett cawley

How many kilovolt ampere (KVA) are the constant frequency generators (CFG) 1 and 2
rated at?

How well did you know this?

Not at all

Perfectly

A constant frequency generator (CFG) comes on line at an input shaft speed between 15,138
and 15,238 revolutions (rotations) per minute (rpm), or about what percent of the proprotor speed
(Nr)?

How well did you know this?

Not at all

Perfectly

At oil temperatures from –54 degrees Celsius (C) to 75 degrees C, the variable frequency
generators (VFG) 3 and 4 are rated at how many kilovolt amperes (KVA)?

How well did you know this?

Not at all

Perfectly

Automatic alternating current (AC) power system control is provided by the

generator control units (GCU).

How well did you know this?

Not at all

Perfectly

What components of the alternating current (AC) distribution system provide current
protection for the suite of integrated radio frequency countermeasures system (SIRFC) and the
aircrew eye respirator protection system (AERPS)?

Circuit breakers

How well did you know this?

Not at all

Perfectly

What alternating current (AC) distribution system component contains contactors, current
sensors, and terminal boards to connect, route, and sense aircraft electrical power?

Power distribution panel (PDP

How well did you know this?

Not at all

Perfectly

What rigid conductive materials jumper electrical power to groups of electrical components
and are pre–shaped to fit in prescribed positions internal to the panel or flexible wiring within the
circuit breaker panels?

Bus bars.

How well did you know this?

Not at all

Perfectly

Which components are cooled by the avionics cooling system?

DC regulated converter (CV)1 and CV2

How well did you know this?

Not at all

Perfectly

In the direct current (DC) power system, what solid–state device contains the timing, logic
circuits, and relay that automatically disconnects the aircraft battery from the ESS/BAT BUS to
prevent excess battery drain during ground servicing?

Battery relay control unit.

How well did you know this?

Not at all

Perfectly

What facilitates the connection/disconnection of the aircraft battery to the MAINT BUS?

RCCB 2.

How well did you know this?

Not at all

Perfectly

What direct current (DC) power distribution system component provides the bus health
monitor function for DC BUS 2, DC BUS 3, and the essential/battery BUS?

Avionics bay interface unit (ABIU)

How well did you know this?

Not at all

Perfectly

How many feed–through capacitor filters are contained in the direct current (DC) power
distribution system?

How well did you know this?

Not at all

Perfectly

What systems are not powered by the external power system?

Nacelle ice protection systems.

How well did you know this?

Not at all

Perfectly

When external electrical power is connected, but not applied to the aircraft electrical
system, the external power box and text is displayed on the cockpit display unit (CDU) as

EXT CON

How well did you know this?

Not at all

Perfectly

The numbers used for reference designators in the wiring system for system, subsystem, and
sub–sub system identification are based on the

unified numbering system

How well did you know this?

Not at all

Perfectly

In direct current (DC) power, what type of cable wiring uses the airframe ground for power
return?

Single

How well did you know this?

Not at all

Perfectly

What tracer color is used with the integrated wiring system (IWS) to identify position 1?

Orange

How well did you know this?

Not at all

Perfectly

What kind of wire harness consists of both conventional (individually shielded and/or
unshielded) wires and integrated wiring system (IWS) wires?

Hybrid.

How well did you know this?

Not at all

Perfectly

How many zones does the flight compartment primary lighting have?

How well did you know this?

Not at all

Perfectly

The three electroluminescent 115 volts alternating current (VAC) lights that provide an
alternate lighting source for illuminating the instrument panel are the

instrument panel secondary lights

How well did you know this?

Not at all

Perfectly

What flight compartment lighting system mode of operation has the maximum brightness
levels set for affected cockpit lights?

DAY NORM.

How well did you know this?

Not at all

Perfectly

What types of cabin lights are identical and interchangeable? Each light contains two
incandescent lamps, one with an opaque lens and one with a green night vision imaging system

Dome

How well did you know this?

Not at all

Perfectly

Operating power and intensity control for the passenger compartment dome lighting and
passenger compartment panel lighting is provided by the

secondary lighting control unit (SLCU).

How well did you know this?

Not at all

Perfectly

What is the length, in inches, of the shorter formation lighting units that are installed on the
inboard top of each nacelle and on top of each aft wing fairing?

How well did you know this?

Not at all

Perfectly

Two light–emitting diode (LED) light assemblies that are installed on the tip of each proprotor blade are

visible from the top and the bottom.

During night vision imaging system (NVG) mode of operation, which anticollision light(s) is disabled?

Bottom anticollision light

How many degrees must the search/landing lights be extended before they can be turned on?

What component provides interface and control for charging power and system logic control for the emergency egress lighting system (EELS)?

Signal conditioning box

What is the minimum time, in minutes, that a fully charged 24 volts direct current (VDC) battery pack contained in the emergency egress lighting system (EELS) control boxes is capable of providing sufficient power to illuminate several emergency egress lighting assemblies?

When the 28 volts direct current (VDC) is removed (power removed from the aircraft), how long will the countdown timer maintain the emergency egress lighting system (EELS) control box in an extended operational state?

1 hour

The lighting control system, through the primary lighting control unit (PLCU), provides operating power and intensity controls for

external lights (position, anticollision, formation, proprotor tip, in–flight refueling).

The primary lighting control panel OVHD (overhead) lighting control potentiometer provides luminance control for zones

3 and 4.

CPLT lighting control intensity of the left main console panel lights increases when the knob is

rotated clockwise

What environmental protection system provides the intake, particle filtration, and high velocity movement of compressed air for use by the environmental control unit (ECU)?

Compression.

What is one of the components responsible for unloading the shaft driven compressor (SDC) during the auxiliary power unit (APU) start up?

Hydraflow surge valve

Controlled by a two–position solenoid valve, the shaft driven compressor (SDC) inlet guide vane is what kind of unit?

Hydraulic–pneumatic.

The shaft driven compressor (SDC) oil filter assembly differential oil pressure pop–out is set for how many pounds per square inch differential (PSID)?

18-24

What provides a path for compressed air from the shaft driven compressor (SDC) surge valve outlet to be exhausted overboard?

Surge valve outlet duct.

What component will provide unfiltered ambient air to the cockpit and cabin in the event of environmental control unit (ECU) failure?

Emergency vent fan.

What kind of filter elements does the inlet particle separator (IPS) filter assembly filters contain?

Two paper fabric internal throw away.

What provides partially conditioned air to the onboard oxygen generating system (OBOGS)/onboard inert gas generator system (OBIGGS), avionics cooling, and the wing pneumatic deice system?

Environmental control unit (ECU).

What environmental control unit (ECU) subcomponent consists of a single platinum element, hermetically sealed in a probe–type housing?

Compressor temperature sensor

Oxygen (O2) tubes are labeled with tape that identifies oxygen tubes with the legend BREATHING OXYGEN and a

green band followed by a band of rectangle symbols

Nitrogen (N2) tubes are labeled with tape that identifies nitrogen tubes with the legend PNEUMATIC and a

blue and orange band of continuous X–formed lattice

How many pneumatically operated engine nacelle pneumatic detector assemblies are attached to each nacelle?

The optical detectors located in the wing aft coves, midwing area, and the dry bays each have a cone field of how many degrees?

120

Within 35 milliseconds after the fire has fully developed, the optical detector will detect a ten inch hydrocarbon pan fire located at a maximum distance of how many feet from each detector?

The fire extinguishing system gas generators suppressors discharge makes up less than what percentage of solid agent?

To extinguish a fire resulting from an incendiary round through the forward spar, the explosion suppression system uses powder panel assemblies that contain

an aluminum oxide suppressant.

In inches, approximately what is the amount of chordwise coverage that the proprotor blade leading edge anti–ice parting strip provides?

How many heater zones does each blade deice distributor (BDD) switch power serially to?

In the ice protection control system (IPCS), what component activates the deice cycle when the ice thickness on any surface reaches a preprogrammed limit?

Master ice protection controller (MIPC).

In what mode, do the ice detectors sense the presence of icing conditions and the anti–icing and deicing is accomplished automatically with no pilot action required?

AIRPLANE

At up to what speed in knots, are the windshield wipers and washer operational?

140

In strokes per minute, what are the two speeds of each windshield washer motor assembly?

120 (low speed) and 180 (high speed).

If the wipers are off when WASHER is selected, how long is the time delay, in seconds, that occurs between the WASHER and WIPER ON commands to prevent wiper operation on a dry windshield?

0.8

What component is designed to reduce rotor-induced vibrations and provide anti-ice protection for the proprotor blade assemblies?

Pendulum damper assemblies

What hydraulic system(s) provide 5,000 pounds per square inch (psi) for blade fold/wing stow system indexing and stowing operations?

No. 3

The planetary assembly is mounted to each

proprotor blade.

What are the indications on the two pairs of wing lock pin safety flags to show the lock pins are disengaged?

Each flag is half black and half white.

Proprotor normal nacelle blower vibration sensors monitor what component’s vibrations?

Proprotor and nacelle blower.

How many levels of adjustment will the vibration structure life and engine diagnostic (VSLED) will calculate for rotor smoothing?

The pylon driveshaft assembly transfers power from the proprotor gearbox to what major assembly?

Tilt axis gearbox (TAGB).

What system transfers power between gearboxes under one engine inoperative (OEI) conditions?

Interconnecting shafting system (ISS)

What type of adapter allows for a more solid connection between a driveshaft and its couplings?

Curvic

What additional component in the left proprotor gear box (PRGB) provides for the counter– rotation of the proprotors?

Idler gear.

How many debris sensors are in each proprotor gearbox (PRGB)?

What is the maximum flow rate, in gallons per minute (gpm) for the proprotor gearbox (PRGB)?

If the dual stage oil filter in the tiltaxis gearbox (TAGB) becomes clogged, what component will ensure oil is supplied to the TAGB?

Single stage oil filter assembly

What component engages and disengages the auxiliary power unit (APU)?

Integral overrunning clutch

What midwing gearbox (MWGB) oil component vents the gearbox to the atmosphere to equalize internal and external case pressure?

Breather.

``` The emergency lubrication system (ELS) oil is not recycled, but passed overboard through what component(s)? ```

Dump valve.

To deliver oil to the low side of the proprotor gearbox (PRGB), what emergency lubrication system (ELS) component does the drive system interface unit (DSIU) sends a signal to?

Oil pump.

The AE1107C basic engine consists of four major assemblies: the power turbine assembly, the torque meter assembly, the accessory drive gearbox, and what other major component?

Gas generator assembly.

What component’s output torque does the torquemeter assembly measure and transmit to the proprotor gearbox (PRGB)?

Power turbine.

What is suctioned through two hydraulically driven blowers to the engine air particle separator (EAPS) and discharged overboard?

Debris

How many seconds does it take the engine air particle separator (EAPS) to cycle from “EAPS OFF” to “EAPS AUTO” or “EAPS ON? “

What kind of fuel filter is housed in the fuel pump assembly?

Disposable 25–micron

Prior to working on ignition system components, as a minimum, how long, in minutes, must the required circuit breakers be open for?

In the compressor acceleration bleed system, compressed air of what compressor stage of the engine is allowed to bleed off during engine start to aid in compressor stall/surge prevention?

Eighth

During emergency engine shutdown, the full authority digital electronic (engine) control (FADEC) keeps what valve de-energized to prevent the flow of air into the nacelle?

Compressor acceleration bleed control solenoid (ABC valve).

The engine oil tank assembly provides oil at a flow rate of 5.5 gallons per minute (gpm) to what component for lubrication of the engine accessory gearbox?

Oil pump.

What does a static cyclonic separator do in the engine lubrication system?

Separate air from the oil.

The oil tank assembly ensures adequate delivery of oil to the engine by the oil pump from sea level up to an altitude of how many feet?

30,000

For identification purposes, what color is the engine monitoring system’s (EMS) electrical harness color–coded?

Green

A controlled engine shutdown occurs if a temperature rise does not occur within how many seconds of initiating the engine start sequence?

What is the maximum number of seconds the auxiliary power unit (APU) can operate in CRANK mode?

The auxiliary power unit (APU) starter is what kind of motor?

High speed.

How many light emitting diodes (LED) are on the front of the auxiliary power unit (APU) built-in-test (BIT) display unit (BDU)?