2007 Seagrave Flashcards
1
Q
engine type
A
Caterpillar C-13
2
Q
engine displacement
A
763 cu in
3
Q
Horsepower
A
485 HP @ 2100 rpm
4
Q
torque
A
1650 lb ft torque
5
Q
fuel type
A
diesel, low sulfur
6
Q
fuel capacity
A
65 gal
7
Q
transmission type
A
Allison 5 speed - Shop #60722 to 60732
Caterpillar- Shop #60721, 60733
8
Q
Drive axle
A
Meritor
9
Q
water tank
A
UPF
500 gal
10
Q
foam tank
A
UPF
30 gal shop no. 60721-60732
50 gal shop no. 60733
11
Q
max height @ deck gun (monitor) handle
A
10’
120”
12
Q
cab height
A
9’2”
110 in
13
Q
cab full tilt height
A
14’7”
176 in
14
Q
length: overall bumper to tailboard
A
28’
337 in
15
Q
wheel base
A
175 in
16
Q
width
A
10’
17
Q
turning radius: wall to wall
A
32 ft
18
Q
steering cramp angle
A
42 deg
19
Q
approach angle
ramp break over angle
departure angle
A
15/11/17 degree
20
Q
vehicle is designed to carry how many people
A
6 people
21
Q
alternator
A
Niehoff 340 AMP
22
Q
foam system Shop no. 60722-60732
A
foam pro 2001 Class A
23
Q
foam system shop no. 60721, 69733
A
foam pro 2001 Class A with 30 gal tank
foam pro 3012 Class b w/ 50 gal tank
24
Q
air restriction indicator max
A
25 inches of water max
25
oil pressure
37 psi @ idle
40 psi @ rated rpm
26
coolant temp max
230F Max
27
voltmeter
12.9 to 14.2 V
28
cab instrumentation indicator light panel consists of how many LED lights
9 LED
29
transmission temp
100 to 250F
30
speedometer; records mileage in what increments
odometer records mileage in .1 mile increments
31
battery charge indicator
10 levels from low charge to fully charged
32
twenty (20) indicator signals to provide three clear levels of concern
1. steady read: critical issues
2. flashing red: issues that may hinder systems operation
3. Steady amber: issues dangerous in nature, but do not impair operation of vehicle or system
33
audible alarms located on dash
constant tone: alarm for stead red or flashing red indicators
intermittent chime: for flashing amber indicators
34
Gear range Caterpillar
1: 2100 rpm 9 mph
2: 2100 rpm 21 mph
3: 2100 rpm 32 mph
4: 2100 rpm 50 mph
5: 2017 rpm 68 mph
6: 1700 rpm 68 mph
35
spring brake automatically apply
40-60 psi in both systems
36
shed voltage
12.2V
37
battery charger electrical connection
110v
38
Elkhart intake relief valve
250 psi
39
steering box and steering linkage, how many inch movements
4" to 6" rapid movements
40
dry vacuum test
at least 20" of vacuum
41
fire pump lube
(right side pump panel)
lube every 100 pump hours
42
oil quantity
36 quarts
34 quarts
43
transmission quantity
Allison: 8.5 gal
Cat: 6.5 gal
44
engine coolant
65 quarts (16.25 gal)
45
pump transmission quantity
12 quarts
46
air brake alarm sounds
85 psi
47
tire pressure
F: 120
R: 90
48
How many removable panels at the cab front for easy service access
4
49
Attention is called to the performance of operation, maintenance, or overhaul, normally in a particular sequence or manner. Deviation from, or disregard of these instructions will lead to serious personnel injury or death of personnel
Danger
50
Attention is called to the performance of operation, maintenance, or overhaul, normally in a particular sequence or manner. Deviation from, or disregard of these instructions may lead to serious personnel injury or even death of personnel
Warning
51
Attention is called to the performance of operation, maintenance, or overhaul, normally in a particular sequence or manner. Deviation from, or disregard of these instructions may lead to equipment damage with resultant loss of the use of the equipment
Warning
52
Attention is called to, or help is given, to a mode of operation, maintenance, or overhaul. It’s intent is to make the application easier and not intended to be a warning or caution as described above
NOTE
53
Use ______, or other material to locate leaks- never use the hands or other parts of the body to detect leaks
Piece of wood or cardboard
54
Battery Charger; indicates charge condition of battery in how many levels
10 levels from “LOW CHARGE” to “FULLY CHARGED”
55
The Seagrave LCD Information Center is a two line, __ character display with an amber LED indicator, a red LED indicator and an hour and minute set button.
20
56
All segments of the digital display are illuminated for more than __ seconds, the ECU did not complete initialization
12 seconds
57
When the digitize display shows a “cat eye”
Selector related fault code has been logged
58
Fluid level check using lever shift selector;
Fluid temp should be above and below what temperature
Above 60*C (140F) and below 104*C (220F)
59
Fluid level check using lever shift selector;
The vehicle should be stationary for approx how many minutes to allow fluid to settle
Two minutes
60
What gear to pull through mud, deep snow, maneuvering tight spaces, driving up or down grades. Provides max torque and max engine braking effect
First gear
61
What gear may be used for vehicle speeds in excess of 46 mph
Gear 5
62
Allison EVS 4000 Transmission Speed Range
1: 2100 Rpm- 14 mph
2: 2100 Rpm- 27 mph
3: 2100 Rpm- 36 mph
4: 2100 Rpm- 46 mph
5: 2100 Rpm- 69 mph
63
If there is no oil pressure indicated within __ to __ seconds, stop the engine and check the lubricating system
10 to 15 seconds
64
Allow engine to idle for how long; this allows the turbocharger adequate time to slow and cool down
4 or 5 minutes
65
Try not to shut down engine unless coolant temperature is ___ or less
195F
66
Use extreme caution when operating the vehicle with either air brake section charged to less than ___ psi or property or personal injury could result
60 psi
67
Total System Manager will check voltage every __ seconds and will only turn OFF one accessory at each voltage check
30 seconds
68
Total system manager; will turn off accessories for how long and must register at least 1 minute of acceptable voltage during the interval
5 minutes
69
Total System manger; once appropriate conditions are met, the Manager will turn on each subsequent accessory every ___ minutes
Two
70
Crew cab Ac controlled by 3 speed:
Low/medium/high
Switch on rear face of overhead AC cover
71
Windshield wiper has ___ different detents
5
Off
Intermittent
Low
High
Wash
72
State of Charge (Voltmeter reading)
100%
75%
50%
25%
12.84 V
12.50 V
12.18 V
11.88 V
73
Voltage supplied to a vehicle’s electrical system must not exceed ___ volts
16
74
Lubricate stub axle and socket assemblies with one of the following recommended greases at regular intervals not exceeding _____ miles or ___ weeks, which ever comes first.
10000 miles
Or
4 weeks
75
Fire pump lube every how many hours
100 hours
76
Cab lift hydraulic Dexron III capacity
6 quarts
77
Power steering
2 qts
78
Kwik Raze lighting maximum efficiency when operated how
Angle of +45 egress
Life expectancy of 10,000 hours
Pressure up to 50 psi
79
Kwik Raze lighting; turn the lamp off at least once a week for a minimum of __ minutes
15 minutes
80
Tires replaced when
Tread depth is at or less than 4/32”
