03-07 Pierce Log Book Questions Flashcards
The logbook __ headings to attract your attention & ___ explain how actions can result in injury or damage?
3 - symbols
Then2003 to 2007 pierce log book contains ___ sections?
5
The information contained in the 2003 to 2007 pierce log book will assist personnel in all the following except…
Pressure governor
What is the number to supply and maintenance division?
(213) 485 6111
This section is to be used for any addendum, updates or changes that occur department wide or specific to this apparatus, tools or equipment.
Addendum
The Waterhouse pump trans gear ratio is?
2.46
The proper battery operational range is?
12.9 - 14.4 volts
Normal radiator fan clutch engagement is?
205
What manufacture is is used for the valves, piping and gates?
Akron
What manufacture is used for the front brakes?
Bendix - korr
What manufacture is used for the rear brakes?
Meritor
What is the Diesel engine horsepower rating?
425 @ 1800rpm
What is the Diesel engine torque rating?
1,550 @ 1200rpm
The 2003 caterpillar C-12 engine that is __ cubic inches?
729
The 2005 and 2007 Pierce used a __ Diesel engine?
C-13
How do you activate the high beam headlights__ until it clicks?
Pull lever towards you till it clicks
What is the normal road transmission temperature?
160-200
When all segments of the trans digital display are illuminated for more than __ seconds, the ECU did not complete initialization?
12
What symbol is shown on the trans display when a fault code is logged?
Cateye
The transmission should be placed in neutral when idling for more than ___ minutes?
5
What is Normal engine oil psi at idle?
10
Does the fuel/water separator have a warning light on the dash?
Yes all pierce
Shall the AC switch be placed in the on position in order to control temperature?
Yes, always
The roof emergency light switch activated how many lights in the light-bar?
5
The steady red activates how many red lights in the light bar?
2
The traffic advisor arrow direction indicator lights is used to ?
Indicates type of flash pattern
The c-12 and c-13 Diesel engine is designed to run at?
Lower rpm
The Diesel engine can run what additional rpm above rated operational range?
7
The cubic inches of the 2005 to 2007 Diesel engine is?
763
The road transmission has how many forward gears?
5
What makes the transmission ECU historical codes so useful?
Determining problems or previous malfunctions
When accesses the trans diagnostic codes, how are the next set of codes viewed?
Press mode
When the ECU detects a problem in the transmission, the ECU will?
Restrict shifting
When the check trans light activates and the ignition switch is off, the trans will?
Remain in N
When checking trans oil level manually, check?
Cold
Engine oil pressure should not drop below what psi at 1800rpm?
30
The ignition switch is a __ style switch that when closed, allows current to flow to specific electrical accessories.
Rocker
Do not shut down engine until coolant temperature is __ or less?
189
During long engine idling periods with the transmission in neutral, the engine coolant temperature may ___ normal operating range
Fall below
The fuel tank holds __ gallons
65
Primary air reservoir gauge denotes the amount of air pressure in the __ axle brake circuit
Rear
Shutting down a turbocharged engine immediately after high speed operation damage?
Turbo seal
The air warning buzzer will shut off when psi reaches?
65 to 75
Discretion must be used when less than how many psi air pressure remains in both air circuits?
90
When the ABS applies the Jacob engine brake is automatically?
Deactivates
At what psi reduction will the spring breaks apply?
40
When pushing the spring brake yellow knob, the auxiliary brake knob will?
Pop out
When the load manager activates, all the following will immediately cancel the system except?
13 volts
When will the load manager alarm sound?
11.9 volts
How many minutes with a low voltage condition activates the load shedding of electrical devices?
1
When the emergency light bar is activated, there is a built in delay of how many seconds between tuning on various lights?
1/2
When the shoreline is plugged in and the power switch is turned on, what light illuminate?
Heater and shoreline
The fire pump recirculating valve, when open flows water from the discharge side of the pump to the water tank through what side line?
1/2”
The kwik raze flood light uses a ___ watt metal halide bulb?
70
The kwik raze flood light lamp has an average life expectancy of how many hours?
10,000
When replacing a kwik raze flood lamp allow to cool for how many minutes?
5
The roof light switch activates the top___ lights in the lightbar & side reds on the roof.
5
Equipped with what size AMP alternator
340
The normal range for the engine coolant 189 degrees to __ degrees?
208
What is the height of apparatus to the top monitor?
10’
What is the apparatus GVWR?
44,000
What is the width including mirrors?
10’
What type of front axle is used?
Oshkosh independent
The water tank is ___ gallons. The manufacture is___?
500 - UPF
The safety vision back up camera screen us used to view through the __ back-up camera?
Right and rear
The electronic foot pedal assembly eliminates the need for any?
Throttle linkage
Pulling the yellow valve knob out will apply the___.
Spring brake
When on scene with all warning lights activated, engage the high idle,. This assist the alternator in keeping up with electrical demands & prevent the __ from cutting out electrical accessories
Load manager
Air conditioner cab air recirculation switch opens or closes all vents to __. This includes heater and air conditioner.
Outside air
The auxiliary front wheel lock is a supplemental brake only, which does not meet the __ parking brake criteria and must be used in conjunction with the yellow parking brake valve when parking the vehicle.
FMVSS
Deck lights switch activates __ on rear tailboard
Pick up lights
The apparatus will not start unless __ has been selected on the transmission
Neutral
What is the maximum mph in 5th gear?
68
A good indicator that all of the moving parts are being lubrication is when the oil pressure gauge registers pressure (at least __ psi) at idle speed.
10
In order to apply the auxiliary front wheel lock the ___ must be applied first
Spring brake
At idle with all electrical accessories ON, system voltage can drop well below 12.0 volts. Even with the engine high idle engaged with all electrical accessories ON, system voltage will vary between __ to__ volts.
12.9 to 13.1
Once the emergency master switch has been toggled, accessories will turn ON in approximately ___ seconds delays.
1/2
Intake relief valve drain: when incoming pressure is greater than___ psi, the intake relief valve will bypass any excessive pressure and water onto the pavement via this 2 1/2” male outlet. Do not Capt his outlet.
250
Two sets of colored LED’s indicate the amount of water in the water tank. The level gauges illuminate only when the __. There is one gauge on each side of the cab.
Fire pump is engaged
The wagon battery consists of a pressure gauge and stacked tips of what sizes?
1 1/2” , 1 3/4” , 2”
Operate priming pump until min suction gauge shows a vacuum of approximately 20” of hg and main pressure gauge shows a positive pressure. Note: if you are not able to achieve prime within__ seconds, stop and investigate.
45