RCM Flashcards

1
Q

The Flash Drum Vessel receives crude from?

A

The desalters

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
2
Q

The heat exchanger trains are typical pieces of equipment for heat recovery. The crude is heated to what temperature?

A

300 degrees F

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
3
Q

What is used in conjunction with the catalyst to reduce Nox?

A

Ammonia

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
4
Q

HAGO is a middle distillate drawn directly from?

A

Tray 15

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
5
Q

Diesel is drawn directly from what tray of the Crude Column?

Which requires further stripping to do what??

A

Tray 29

Remove light ends

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
6
Q

Kerosene is a middle distillate drawn directly from which tray
of the Crude Column?

Which requires further stripping in order to remove the light ends. What is unique about this stripper?

A

1) Tray 42

2) uses superheated steam

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
7
Q

Heat to the Kerosene reboiler is provided by?

A

LCR

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
8
Q

A High level in the Crude Column will cause the steam to do what?

A

Trip closed

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
9
Q

What is the purpose of the Crude Column Hot Accumulator?

A

Provide reflux to the top of the crude column

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
10
Q

What provides the Cooling/Condensing of the overhead gas?

A

Raw Crude

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
11
Q

Lquid from the Cold Accumulator is normally pumped to the?

A

RA Column

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
12
Q

The CDU overhead has how many compressors?

A

2

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
13
Q

What provides the cooling for the discharge of the compressor first stage?

A

Fin Fans

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
14
Q

There are how many HVU heaters?

A

2

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
15
Q

What steam pressure is injected into the HVU heater passes?

A

600LB

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
16
Q

The HVU column separates the Atmospheric Residue into how many streams?

What are the streams?

A

Four

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
17
Q

How many circulating reflux systems are there on the HVU Cloumn?

A

3

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
18
Q

The heater firing controls are designed to avoid?

A

Flooding the heater

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
19
Q

The depropanizer produces _____ and _____?

A

Propane and Butane

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
20
Q

Depropanizer charge comes in as heated _____ from the _____?

A

LPG from the Merox

How well did you know this?
1
Not at all
2
3
4
5
Perfectly
21
Q

Amine treated LPG is blended with _____ to remove the remaining ______.

A

Caustic

Mercaptans

22
Q

The heater on the oxidizer is typically used during?

A

Cold weather

23
Q

Air, disulfide rich wash oil and caustic are separated in the.

A

Disulfide Separator

24
Q

What removes the residual COS Solvent before the Propane is sent to storage?

A

Propane Sand Filter

25
Spent Air mixture flows through the Merox Vent Tank then through two______ and on to an incinerator at the SBU?
Flame Arrestors
26
What is used as an instrument purge gas?
Natural Gas
27
What is the purpose of the Ejector Effiuent Vapor Separator What is the common name for this vessel?
Separate Vaccum overhead gas into oil, gas, and water Process Drum
28
The Ejector Efluent Vapor Separator is a 3 phase separator, what are the phases?
Oil Gas Water
29
The Amine Absorber is located?
Down stream of the KO Drum
30
There are two LRP's downstream of the 2" stage jets. What is the backup?
3rd Stage Jets
31
What is the purpose of the Desalters?
Remove salts and sediments from the Raw Crude
32
What two types of Demulsifiers are available for use?
Oil and Water
33
What happens with a low differential pressure going into the desalters?
Loose Emulsion
34
What process occurs in the Desalter Brine Surge Vessel?
Sponge Oil comes off the top, oily water from the bottom to the Tetra Unit and Brine to the filters.
35
What are the three operational modes of the filters?
Isolate Backwash Service
36
A reverse emulsion breaker at the brine de oiling unit is used to?
Seperate the emulsion
37
Because of the type of resin bad used in the filters, thare is a settling period of ______ when going into and coming out of backwash mode?
2 minutes
38
The three main locations where 600 pound steam is used on VPS5?
Flash Crude Turbine Debutabizer Reboiler HVU Heater Passes
39
What cools the VGO and Resid streams?
Tempered Water
40
What cools the VGO and Resid streams?
Tempered Water
41
What is used as a purged and ignition gas?
Natural Gas
42
What are four uses of fuel gas?
Heaters Desalter Water drum Vacuum Breaker ????
43
What are some of the uses of the VGO purge oil system?
Maintain purge oil pressure on pump seals & instrument purges
44
Name the five flare drums?
HP LP MEROX BRINE DEOILER OFFSITE
45
Low pressure gas from various operating units is routed to the?
SGP Wet Gas Compressor
46
In the event of a wet ga compressor trip the gas is automatically routed to?
FGP Scrubber
47
The RA Column separates ______ and lighter gases to send them to the Fuel Gas Plant?
Ethane
48
The butane, propane and naphtha go out the _____ of the RA Column for further processing?
Bottom
49
Cooled naphtha is added to the RA Column overhead from the ______ to help with additional Low Pressure Gas recover.
Bottom of dehutinazier
50
The bottom product of the Debutanizer is _____ to the NHTU for further processing?
Stabilized Naptha