MAY 2018 AST1 Flashcards
1
Q
Fire starter goes in what pocket of LPU-26?
A
Wearer’s left pocket
2
Q
Desalinization pack goes in what pocket of LPU-27 PEG vest?
A
Wearer’s right middle pocket
3
Q
Scuba bottle for servicing SEAS-1 should be how many cubic feet?
A
- 80 or 90 cubic feet
4
Q
How many portable fire extinguishers on HC-144?
A
There are three portable extinguishers in the aircraft: one in the flight compartment and two in the cargo compartment
5
Q
Middle compartment on 65 float is initially inflated to how many PSI to check for internal leakage?
A
- 0.75 PSI check, 3.48 PSI 30 minute check, 3.0 PSI 3 hour leak check, can deflate to 2.25 PSI after leak check
6
Q
Training seas bottle is what color?
A
Black and shall stencil “training use only” in white ½” stencil
7
Q
Receiver for PYRO from a life raft marks the pyro what ATR code?
A
The issuer of the life raft pyrotechnics shall use the ATR code of “INSTL” to remove it from the Ordnance Information System (OIS). The receiver of pyrotechnics from a life raft shall use the ATR code of “UNPAC” to acknowledge receipt in their ATR.
8
Q
ADS bag or bib needs to be replaced if it has a tear how long?
A
-Deployment bags and trail line bibs that have tears longer than 3 inches or holes larger than 1 inch
9
Q
ADC assembly protects you from 32 degree water for how many hours?
A
The ADC assembly will afford protection from exposure to 32 °F water for a period up to 14 hours
10
Q
CG22 that for urgent flight related info, but not flight safety has how many days to be complete?
A
-The available priority codes are:
Urgent — 7 days from receipt of the CG-22 to distribution to the units
Non-routine — 14 days from receipt of the CG-22 to distribution to the units
Routine — 90 days from receipt of the CG-22 to distribution to the units
11
Q
Re-inspection of unit with major armory must be within how many days of failing pyro inspection?
A
- The re-inspection of units with major discrepancies shall be conducted within 90 days to verify conformance with policy
12
Q
LRU-33 bottle has no more than how many pounds of CO2?
A
3.06 pounds of CO2, and 5.7 pounds of N2 A
13
Q
Max C02 in SEAS1 breathing air PPM?
A
air requirements as depicted below: (1)CGA Modified Grade E (ANSI/GCA G-7.1) (2)Oxygen 20-22% (3)Carbon Dioxide (CO2) 500 PPM (4)Carbon Monoxide (CO) 10 PPM (5)Methane (CH4) 25 PPM (6)Water Vapor 67 PPM (7)Dew Point -50 °F (8)Odor - none`
14
Q
Do what to the ignition coil on the pump during the post use inspection?
A
nspect for corrosion and obvious damage, remove and replace for post SAR inspection
15
Q
The temperature calculator for inflatables uses what number?
A
- 0.03
16
Q
Aircrew safety belts ends are folded how many times and how many layers are they?
A
Four thickness fold
17
Q
Triton harness torso length adjusters are folded how many times
A
- 3
18
Q
Aircraft safety belt inspection shall not exceed how many days?
A
A visual inspection will be accomplished at intervals not to exceed 30 days. Aircraft safety belts issued to rescue swimmers shall be visually inspected each duty day.
19
Q
Type XIII breaking strength?
A
-7,000lbs
20
Q
What color is the float inflation bottle?
A
Grey
21
Q
How many raps through the eye splice of the manila for the trail line on the ADS?
A
- Wrap one end of the polypropylene line three times through either manila line eye splice.
22
Q
Pre-mission servicing icon button in EAL?
A
- Blue
23
Q
MA-1 leak check fill to what PSI?
A
- MA-1 walk around cylinders are painted yellow in accordance with MILSTD-101.
200 PSI, no leaks charge to 375 PSI.
24
Q
CASA oxygen subsystems?
A
-The system has two different installations: a fixed one for the crew, and a portable one for the passengers and emergency conditions.
The portable installation is: six high-pressure oxygen bottles, two located in the fixed rack, two in the Mission System Pallet (only in the MPA configuration) and two in the rear part of the cabin
25
60 windshield washer fluid PSI?
-65 is 14.5 PSI
26
If you order priority 5 item how many items will they have on the shelf at ALC?
- Priority 5 requisitions will be filled if there are more than two parts on the ALC shelf. Priority 12 requisitions will be filled if there are more than five parts on the ALC shelf.
27
Non mission essential aircrew SWET training and EGRESS?
underwater egress training within the preceding 75 calender months aviation water survival training, and a swim test within the preceding 24 calendar months
28
VERT surface shall be completed how often?
12 months
29
Cubic feet of oxygen in EPOS?
The EPOS contains one oxygen cylinder filled with 18 liters of aviator grade oxygen, and incorporates a rupture disk to safely vent excess pressure. The system consists of five major components: hood, oxygen cylinder, carbon dioxide controller, neck seal, and storage pouch
30
PPM for water and in fuel?
10 PPM
31
How far for non-smoking sign for servicing oxygen?
When handling liquid oxygen, signs should be posted in the area that restrict smoking, open flames or sparks within 50 feet of the handling area. Avoid sparks, flames and other ignition sources in areas where oxygen is handled. ‘NO SMOKING’ signs should be conspicuously posted.
32
How far can be lightning be from servicing oxygen?
5 miles
33
How long after hot purging must you service oxygen system?
Hot purging of liquid, low- and high-pressure systems will be accomplished every 200 hours. Regardless of the hot purging agent used, the converter must be purged with cold gaseous oxygen for 15 minutes or until ambient temperature is reached prior to refilling with LOX.
34
When hot purging oxygen how long does it have to flow through converter?
The recommended duration for hot gas purging each standard size converter is as follows.
5 liter capacity: 20 minutes minimum, after heat stabilization. 10 liter converter assembly: 30 minute minimum, after heat stabilization. 25 and 75 liter capacity: 45 minute minimum, after heat stabilization.
The maximum hot purge duration will be determined by the operator. Based upon the condition of the converter, environmental conditions, and previous maintenance.
35
While decontaminating 60 how long do you let decontamination solution sit?
- 10 minutes
36
Life limit for aircrew safety belt?
Both fixed and rotor wing crewmember aircraft safety belts have a 5-year service life and should be removed from service if item is past its life limit.
37
Rag storage bin for solvents rags must be emptied how often?
- End of the day.
38
Who can delete a discrepancy in ALMIS?
Maintenance release authority
39
Towing C144 minimum personnel?
- C-144: 6 C-130: 7
40
No more than 50 darned areas in how many adjacent panels?
-Not more than 50 darned areas shall be permitted in any adjacent eight gores, and no more than 200 darned areas shall be permitted in any canopy.
41
No more than 50 darned areas in how many adjacent panels?
-Not more than 50 darned areas shall be permitted in any adjacent eight gores, and no more than 200 darned areas shall be permitted in any canopy.
42
Who authorizes survival kit?
Personal survival kit: The contents must be approved by the unit Engineering Officer, and inspected in conjunction with annual flight gear inspections. Procurement authorization is only for procurement of AASK, CWASK, and the ADSK related equipment. All other survival equipment deviations must be authorized through ALSE Technical Services. Contents of the AASK, CWASK, and the ADSK will vary depending on the geographical operational areas with advances in commercial survival equipment technology, equipment that is better suited for a given unit’s geographical operating area may be commercially purchased at the Commanding Officer’s discretion.
43
What knot for the bow tie?
- Bow ties may be hand tied or a clip on type, approximately 4 ½ inches wide. For ties: The Double Windsor tie knot is the only authorized knot. A tie tack or tie clasp may be worn
44
Other than the SDB what is the only other authorized uniform of the day?
- The standard Coast Guard uniform of the day, regardless of season or location, is Service Dress Blue (SDB) or Tropical Blue (TB) uniform
45
Where does pile go on swimmer helmet?
- Apex of the helmet
46
Block size for measuring for a helmet?
Wood block (2 x 4 x 8 inches)
47
Thermometer is calibrated in pyro locker how often?
Thermometers shall be calibrated every 3 years
48
temperature and humidity is checked how many times a day?
- Recordings of these variables shall be taken at least three times daily using the relative humidity and temperature indicator.
49
Consew Sewing machine is a ______(double, single, triple?) feed type?
- Triple feed
50
MK-58 burns for how long maximum?
- 40 to 60 minutes
51
Ailerons provide stability for aircraft in what direction?
- The aileron trim system is used for roll axis trim
| - The elevator trim system is used for pitch axis trim
52
What are primary flight controls on C130?
- The primary flight controls include the ailerons, rudder, and elevators
53
The USA symbol on icom radio is where?
- Top left corner
54
Primary force on spinning rotor blade?
The rotor head center hub forms a star with four arms which are flexible in the flapping axis, but rigid in the lead/lag axis. The rotor blades are connected to the center hub by means of rigid attachment bars that permit flapping, drag and pitch change functions through the use of laminated spherical thrust bearings and sheer−deformable frequency adapters. An anti− cone stop for each blade facilitates starting in high winds. Centrifugal force causes the stops to retract as rotor speed increases. When the rotor speed decreases, the stops are extended to their initial position by return springs. Spring activation is between 181 and 202 RPM
55
Aileron goes down camber goes? up/down lift goes? up/down
- Ailerons go down for more lift, up for less lift. The ailerons do the same thing as the flaps: They increase the camber line (curve of the wing), which increases lift and drag. The rudder changes the camber of the vertical tail and causes its lift forces to be exerted left or right
56
How long after LCI inspection does LCI have to give report to ALC ESD?
10 days
57
How long before LCI inspection is unit notified?
60 days
58
What manual is LCI Inspection in?
- Logistics Compliance Inspection (LCI) Process Guide, CGTO PG-85-00-300
59
Casa fire bottle can lose how much weight per year?
- Fixed bottle 0.10, handheld is 0.5 ounces or 14.17 grams per year
60
Casa oxygen bottle is shipped at what PSI?
This note applies to oxygen cylinders and LOX containers that are used in aircraft and are shipped by commercial carriers. The vessels prior to shipment will have the pressure reduced to 24 pounds per square inch gauge (psig).
61
Color coding?
Red is areas that contain fire extinguishers and firefighting equipment. Yellow is used for paint striking, stumbling, and falling hazards. Orange is the standard color for hazards which cut, crush, burn or shock. Blue is used for the outside of switch and fuse boxes, control panels, off and on control boxes on machinery. Green is first aid and medical cabinets, stretcher boxes, cabinets for gas masks, safety showers, and all signs relating to first aid.
62
Price of messing with a 1577-2 is?
- A fine of not more than $1,000 or imprisonment for not more than 1 year or both.
63
How many Attachments for a CG22?
- A total of six attachments may be added for each CG-22. Once six attachments have been added, the next role level will not be able to add any attachments
64
How long can female finger nails be?
Will not extend more than ¼ inch beyond the fingertip.
65
Hypothermic double lift can take as long as?
- Based on the position, size, and/or physical condition of the survivor, the double lift may require up to 20 minutes to complete.
66
Maternity uniform can be worn for how long after you have a baby?
- Maternity uniforms may be worn by women during pregnancy and up to 60 days after returning from maternity leave
67
Incumbent OIC badge goes where?
If assigned as incumbent CO or OIC, device is worn centered ¼ inch above nametag on right pocket. Embroidered insignia, command devices, incumbent Command Chiefs, and RFMC badges are authorized on the ODU.
68
Male hair bulk in inches?
- Men: The bulk of hair must not be more than 1-1/2 inches from scalp. Women: No portion of the bulk of the hair as measured from the scalp will exceed 2 inches.
69
Length of shoe-laces for boots zipper?
A 30-inch lace (i.e., NIIN 00-205-2760) should be used to lace in the insert.
70
Hazardous materials manual?
- CGTO PG-85-00-1660-A
71
Color of Pre-mission servicing ICON in EAL?
- Blue
72
Color of Pre-mission servicing ICON in EAL?
- Blue
73
C144 fire extinguisher hydro cycle?
- 60 months, 12 years for handheld
74
C144 fire extinguisher cartridge expiration?
- Life limit is 6 years of DOM, service life (installed on aircraft) is 4 years
75
How many commands when entering MPC card in EAL?
- 1. Execute 2. Remarks 3. Signoff type 4. Clear 5. End 6. Quit
76
Running pump transit cytometer 1400 +- how many?
+/- 200
77
Number of characters in SCHR comments?
- 600 characters
78
Pull test for LRU-25 can fail how many times before you have to send it back to ALC?
- 2 times
79
Joint oil analysis manual?
- NAVAIR 17-15-50.1
80
What manual is the hazmat disposal manual?
COMDTINST M16478.1
81
C130 inertia reel locks in impact of how many G forces?
The reel harness cable will automatically lock when an impact force of 2 to 3 Gs’ on the airplane is encountered.
82
PDM reports come out how often?
- ALC will publish a message each quarter with the proposed PDM schedule for the next six months for the four main aircraft types
83
Irreparable aircraft components are tagged with a tag 1577- what?
-1577-2 (blue) this form will be attached to an unserviceable item that is non-repairable at ALC and will be sent to an outside vendor or manufacturer for repair. DD-1577 Unserviceable (Condemned) Tag red.
84
When do you use local time for EAL?
- Flight schedule
85
When looking for your PDE on direct access you press what tab?
- DA self service, View tab
86
EPOS shelf life years?
- The shelf life of the passenger oxygen (PAX) mask is six (6) years from the date of manufacture. Once installed within the allowable shelf life, the PAX mask may remain in service until it shows signs of deterioration or is damaged.
87
Who authorizes change in uniform for injured personnel?
- Commands have discretion after consulting with competent medical authority regarding alternate uniforms (e.g., ODU vs. Tropical Blue), to include soft sole shoes or suitable civilian clothing. Commands shall ensure that members who are Not Fit For Duty (NFFD), and authorized temporary uniform of the day alternatives maintain a conservative and professional image.
88
Who authorizes permanent shaving chit?
- Commanding officers or officers-in-charge will grant permanent shaving waivers for personnel who have received a confirmed diagnosis of Pseudo folliculitis Barbae (PFB) by a medical doctor providing health care for unit personnel. PFB waivers are permanent and do not require renewal upon transfer. If waiver approved, members will not shave any facial hair. Facial hair will be trimmed so as to not exceed ¼ inch in length.
89
What percentage do you fill the LM05HP? LOX cart to?
- LOX bulk storage tanks shall not fall below 15 percent of the maximum full capacity of the tank or trailer. The LOX facility manager shall schedule LOX procurement before or when a storage tank or trailer has reached 20-percent capacity.
90
When removing C144 bottle well marked signs for no smoking should be how many meters?
- 10
91
How often is ground egress training?
- Once per calendar year
92
How often is ground egress training?
- Once per calendar year
93
Who approves higher level of EMT training?
-Units desiring to maintain higher EMT levels of training should obtain authorization from CG-711.
94
How long is the aircrew swim test?
-75 yards
95
What two forces are involved in a bending motion?
- Bending occurs when the forces of tension and compression occur together
96
A constant speed prop does what to adjust power?
- Control fuel flow
97
Overpressure PSI for T-foamer?
- 125 – 135 PSI
98
How many knots wind speed do you need a waiver for jacking a C130?
- 15 knots
99
How long can cement for life raft sit out before you have to dispose of it?
- 4 hours
100
How many minutes for afloat hearing conservation?
- 8 hour work day, 85 dB or greater single hearing protection, 96 dB or greater double hearing protection.
101
A hazard must be included in abatement plan if it is not remedied within how many days?
- 30 days
102
What is included in the GAR model to assess risk?
- The PEACE/STAAR analyses are captured in GAR 2.0 to make warranted risk decisions
103
SDB regulations?
- Uniform regulations COMDTINST M1020.6I
104
How many minutes for stretching after working out?
- Hold the static stretch until you feel the muscle loosen, hold for 15 seconds, release, and then repeat.
105
How many minutes a week for vigorous physical activity?
- According to the CDC, adults should perform 2 hours and 30 minutes (150 minutes) per week of moderate-intensity aerobic activity or 1 hour and 15 min (75 minutes) per week of vigorous-intensity level or an equivalent mix of both is recommended
b. Aerobic activity should be performed for at least 10 minutes at a time and spread throughout the week.
c. For greater health benefits, 5 hours (300 minutes) per week at a moderate-intensity level or 2 hours and 30 minutes (150 minutes) at a vigorous-intensity level or an equivalent mix of both is recommended
106
C144 hand fire extinguisher bottle weight loss allowable limits in grams?
- The allowed weight loss is 0.5 oz (14.17 gr)/year provided that this weight loss does not exceed 2 oz (56.7 gr) below the initial charge weight
107
C144 fixed system bottle weight?
- It has a maximum weight of 6.49 Kg (14.3 lbs) in a charged condition at 22°C (72°F) temperature
108
How many tucks for splicing ASRK build-up?
- Route either end of polypropylene line through eye of a snap hook and attach with an eye splice, using
6 tucks minimum per splice.
109
As per personal fitness manual how long do you stretch?
- Each time you perform aerobic or strength-training activities, take an extra 10 minutes to stretch the major muscle groups. Hold stretches for 10 to 30 seconds and repeat 3 to 4 times.
110
What can you not wear during a uniform inspection?
- The unit ball cap is an optional item, not a sea bag item, and cannot be mandated for wear onboard units or for inspections. Cell Phones, Pagers, Handheld or Pocket Electronic Devices, Headphones, earphones, or Bluetooth type devices are not authorized if participating in ceremonial details, while in formations, or while performing unit functions (i.e., colors, inspections, or all hands).
111
How often does the EO review log books?
- The Engineering Officer or a designated representative shall conduct a monthly review of each asset logbook as a quality assurance check of Asset Computerized Maintenance System (ACMS) management procedures. Paper logbooks- The Engineering Officer or their designated representative shall review these forms on a daily basis. It is important that discrepancies which affect flight safety or system operations not be overlooked.
112
How long are paper versions of aircraft logbooks kept?
- 90 days
113
What kind of fire is an electrical fire?
- C
114
Squib service life?
- Replacement squibs, P/Ns 074053-1, 4199-1, and 802465-2, NSN 1377-00-677-6281, have a shelf life of 84 months and a service life of 60 months.
Replacement squib, P/N 834AS450, NSN 1377-01-377-9215, has a shelf life of 108 months and a service life of 48 months.
115
What is the cubic footage on EPOS?
- 10 years 6 months from date of manufacture as long as the protective pouch has not been compromised. One 98 cc volume aviator grade oxygen; 3000 psi working pressure
116
How much do you deplete an O2 bottle to ship?
- 24 PSI
117
What is not required at switchboards?
- Required at switchboards: Electrical matting is provided where required, Grab rails are in place at switchboards, Install battle lanterns and properly direct them in the vicinity of all electrical switchboards, generators, steering and diving panel, engine and fire room gauge-boards, control bench board, propulsion and boiler controls, boiler water gauges, and equipment associated with steering
118
Who designates professional development coach?
- CO
119
Where is the RS drysuit pen pocket located?
- A pen pocket is located on the left shoulder
120
Max wait time after shut down to do JOAP? Check MPC 71001.7
- All samples should be taken within 15 minutes of engine shutdown after a ground run at 355 RPM, and prior to servicing. Ensure all sampling materials are clean and free of contaminants.
121
What is the PQDR process guide?
- Joint deficiency reporting system (JDRS) process guide: CGTO PG-85-00-1320-A
122
How long in advance is a unit notified of an upcoming LCI?
- 60 days out CG-41 Notification letter due to unit. 10 days out Unit EO Unit read-ahead due to LCI Team Lead. 10 days after Team Lead Draft final report due to ESD (ALC Team Lead). 20 days after ESD Draft final report due to CG-411. 60 days after CG-41 Final report due to unit. 45 days after receipt of the CG-41 final report, unit corrective action required for discrepancies as identified by LCI Team. Deadlines will be specified in final report
123
How long does LCI inspector have to turn in his report?
- 10 days
124
If an E-7 does not want to stand duty you have to notify whom?
-Aviation Survival Technicians (AST) from pay grade E-7 thru E-9 are not required to participate as an operational RS. Those that choose not to participate are required to notify CG-711
125
You have 140 items on supply record you are allowed______ discrepancies?
- 01
126
How many categories of PQDR are there?
- A PQDR will be classified as Category I or Category II.
127
How many tucks are required for splicing?
- Pass each strand over the adjacent strand and under the next strand until three to four tucks have been made in each strand. With polypropylene line, carefully sear the bitter ends, being careful to avoid damaging the body of the splice.
- Trail line: At one end, splice a snap hook onto the line using a 3-inch eye splice with a minimum of four tucks. Trim and carefully sear excess line. Measure and cut one 18-inch length of Type III nylon cord. Remove and discard inner core lines. Sear ends of cut sleeve. Form a loop and secure with a surgeon’s knot and a square knot, leaving approximately 2 inches on each bitter end.
128
How often do you test oil lubricated compressor for filling SEAS?
-Air stations with SEAS-1 breathing air compressors lubricated with oil shall be tested quarterly. Compressors lubricated with non-oil lubricants (water, etc.) shall be tested semiannually.
129
Who authorizes CSE confined space engineer?
co
130
What color for jumbo size gumby suit bag?
- Any individual who is 6 ft 4 in tall or taller will need to utilize a jumbo size suit, identified by the green stowage bag labeled “jumbo” from the manufacturer. The size most commonly used is Adult Intermediate. This will be found in an orange bag from the manufacturer.
131
How many months of schooling does the post 911 bill provide?
- 36 months
132
How often is detailed safety inspection?
- At least annually
133
Life limit of 65 float bags?
- 9 years 6 months
134
How long do you have be qualified at current position at unit to be considered for instructor?
- At least 6 months
135
What size drill bit is used to drill NVG eyelet?
- Enlarge small hole of the NVG Retention Lanyard Eyelet with a No. 30 drill bit.
136
What size drill bit is used to drill NVG eyelet?
- Enlarge small hole of the NVG Retention Lanyard Eyelet with a No. 30 drill bit.
