F550 Brush Pumper

Question 1

Length (short)

Answer 1

22’ 3”

Question 2

Length (long)

Answer 2

24’ 3”

Question 3

Width

Answer 3

8’ 3”

Question 4

Height

Answer 4

7’ 1”

Question 5

Weight (long)

Answer 5

22,832 lbs

Question 6

Weight (short)

Answer 6

21,832 lbs

Question 7

Fuel capacity

Answer 7

40 gallons

Question 8

Engine oil

Answer 8

13 quarts 15W40

Question 9

Transmission fluid

Answer 9

18.5 quarts mercon

Question 10

Pump

Answer 10

Hale HP 100

Question 11

Booster tank (short/long)

Answer 11

Short: 300 gallons

Long: 400 gallons

Question 12

Turning radius

Answer 12

53.3 ft

Question 13

Pump oil

Answer 13

SAE 30 1.75 quarts

Question 14

Diesel exhaust fluid

Answer 14

6 gallons

Question 15

Aux pump oil

Answer 15

SAE 30

Question 16

Transfer case oil

Answer 16

80/90 gear oil

Question 17

Where is radiator sight glass located?

Answer 17

Rear of radiator, right of center

Question 18

Where do you check the oil?

Answer 18

Right (officers side) toward middle of motor

Question 19

Where is transmission fill?

Answer 19

Left (driver side) of engine at rear of motor

Question 20

4x4 light and LOW RANGE light located where?

Answer 20

Lower right of instrument cluster

Question 21

2H position

Answer 21

Neither 4x4 or low range lit

Question 22

4H position

Answer 22

Only 4x4 lit

Question 23

N position

Answer 23

Neither 4x4 or low range lit

Question 24

4L position

Answer 24

Both 4x4 and low range lit

Question 25

4H to 2H should be done at what speed?

Answer 25

Any speed

Question 26

On hard pavement in 4WD do not exceed _____ mph

Answer 26

20 mph

Question 27

When starting pump, throttle control should be in what position?

Answer 27

Mid throttle position

Question 28

Prolonged cranking of more than ____ seconds can damage starter motor.

Answer 28

15 seconds

Question 29

What valve should be pulled for prolonged running of engine without flowing water?

Answer 29

TANK FILL and BY-PASS

Question 30

The only way to get more discharge pressure?

Answer 30

Using smaller tips

Question 31

Joystick direction for straight stream and fog stream.

Answer 31

RIGHT for STRAIGHT LEFT for FOG

Question 32

Front bumper winch is used for what?

Answer 32

Self extrication OR assisting other brush pumpers

Question 33

Max load for winch

Answer 33

8000 lbs

Question 34

Booster line on which side? High pressure line on which side?

Answer 34

Booster- drivers side High pressure- passenger side