Engine Room Flashcards
What’s is the Length
42’
Beam length
13’ 8”
Dead rise
22 degrees
Engine stats
Cummins QSB 6.7
550 hp
Transmission info
ZF 280
Jets info
Alamarin 340
Fire Pump type
Darley 3000
Generator brand and output
Onan
7 kw
Gross tonnage
24,581 pounds
How deep are gutters for engine room
4 inches
Engine room Bilge pump flows what
2700 GPH
What type of float switch on the engine room bilge
Ultra Safety Systems Senior float switch
How often should bilge pump be checked
Monthly
Bilge must remain ______ and _______
Dry and clean
How many quarts to get oil from low to high
2 quarts
How often must oil be checked
Daily
What is the oil capacity
15 quart pan, 17.6 quarts for oil change with filter
Type of fuel water separator
Racor 500
10 micron
Checked daily and at each refueling
Always fill oil from where and why
Oil cap instead of oil change system since there will always be dirty oil in the hose lines
How long should engine be run before checking transmission fluid
Run 2 minutes, turn off and wait 2 minutes
Place what under the transmission
Diapers
Every seacock will have a _____ since its an aluminum boat vs a bonding system in a fiberglass boat
Zinc
Use ______ to push out debris from seacock
Clean out rod
The metal craft has what type of engine cooling system
Water cooled
What brand of engine sea strainers do we have
Groco
What should all zincs be painted with
Purple nail polish with a Z
What type of exhaust is in the engine room
Wet exhaust
What are the types of breakers on the generator and where are they
DC on the front and AC on the forward panel
What is on the front panel of the generator
Oil and fuel filter, fuel pump, belt, fuel lines
Brand of fuel filter
Racor
Where is the generator fuel pickup in the tank in relation to the mains pickup
Higher than the main to leave fuel for mains
What type of shafts are in the engine room
Spicer shafts
Type of jets
Alamarin AJ 340 Jets
Types of hydraulic fluid reservoirs in the engine room
Jet Bearing and Reverse deflector
Fire pump is rated at what
3000 GPM
How many people does it take to remove the sea chest
2
How many sections is the sea chest
2 sections
Person ____ will remove each section of sea chest and hand to the _____ person
Forward
Aft
Check _____ to ensure a proper seal is made
Gaskets
Do not exceed how long when priming the pump
30 seconds
Fire pump should not be ______ when priming
Engaged
Oil change system is called
Reverse
What does 1 tape mean on the reverse oil change system
Engine
What does 2 tapes on the reverse oil change system mean
Transmission
What do the following colors mean on the reverso oil change system:
Red
Green
White
Red= Port
Green= Starboard
White=Generator
With regards to the reverso oil change system:
All valves must be _____ during normal operation
Closed
How do you know if the battery charger is on
Green light
What voltage is the battery system
12 volt
What is the heat detector in the engine room set at
190 degrees
Where is the high heat alarm located
Bilge panel in the pilot house
How many gallons is the foam tank
40 gallons
What type of anchor is the aft anchor and what is the rope and chain length
Danforth
200 foot rope
22 foot chain
